DragRaceResults.Com    Bracket Talk    Bracket Talk Forum  Hop To Forum Categories  Tech Talk - by Abruzzi    1993 club car Gas DS golf cart died
Go
New
Find
Notify
Tools
Reply
  
1993 club car Gas DS golf cart died
 Login/Join
 
DRR Sportsman
Picture of fast frank
posted
was driving, then just died,now wont do anything. battery is good. lights work but wired separate off the battery. wont even turn over. where to start? thanks

This message has been edited. Last edited by: fast frank,
 
Posts: 728 | Location: pa. | Registered: December 21, 2005Reply With QuoteReport This Post
DRR Trophy
posted Hide Post
Don’t know a lot about them but I would think I’d start with is the gas pedal getting power and is it sending a signal to module for it to start
 
Posts: 386 | Location: Natick MA | Registered: November 15, 2017Reply With QuoteReport This Post
DRR Trophy
posted Hide Post
gas or electric?

If electric, is it 48v, 36v??? What model? DS or??

if Gas What engine??
 
Posts: 104 | Location: Il,IL | Registered: March 22, 2021Reply With QuoteReport This Post
DRR Sportsman
Picture of fast frank
posted Hide Post
quote:
Originally posted by M802138:
gas or electric?

If electric, is it 48v, 36v??? What model? DS or??

if Gas What
gas DS believe it is a Kawasaki
 
Posts: 728 | Location: pa. | Registered: December 21, 2005Reply With QuoteReport This Post
DRR Trophy
posted Hide Post
Try turning the starter generator motor a 1/2 turn by hand press gas see if it takes off? If it does run your, starter generator is bad. When you replace it spend the extra 20 bucks and replace the voltage regulator also. A bad regulator will kill your starter generator.
 
Posts: 6 | Location: Michigan | Registered: April 11, 2011Reply With QuoteReport This Post
DRR Pro
Picture of Goob
posted Hide Post
Probably should check the fuse.


"Despite the high cost of living, it remains popular."
Dave Cook
N375
 
Posts: 1622 | Location: Indy | Registered: November 21, 2008Reply With QuoteReport This Post
DRR Trophy
Picture of PineApple Express Racing
posted Hide Post
I had the same problem. Had ladies and kids in the car. Dead in the staging lanes. Took it home and chased the dogs tail. Found the engine oil low. Added oil and started right up.
 
Posts: 113 | Location: Las Vegas USA | Registered: July 08, 2005Reply With QuoteReport This Post



DRR Sportsman
Picture of fast frank
posted Hide Post
it turned out to be the microswitch behind the shifter under the seat. thanks
 
Posts: 728 | Location: pa. | Registered: December 21, 2005Reply With QuoteReport This Post
DRR S/Pro
posted Hide Post
quote:
Originally posted by fast frank:
it turned out to be the microswitch behind the shifter under the seat. thanks


Is that the big single motor or twin?
Front of the motor down low is an electronic black box. Rpm limiter, when it quits- so does the engine. If and when it fails. You can bypass but it runs better with it.


Raceless in California!
 
Posts: 4480 | Location: Vacaville  | Registered: January 07, 2004Reply With QuoteReport This Post
  Powered by Social Strata  
 

DragRaceResults.Com    Bracket Talk    Bracket Talk Forum  Hop To Forum Categories  Tech Talk - by Abruzzi    1993 club car Gas DS golf cart died

© DragRaceResults.com 2024